帳號:guest(34.204.52.16)          離開系統
字體大小: 字級放大   字級縮小   預設字形  

詳目顯示

以作者查詢圖書館館藏以作者查詢臺灣博碩士論文系統以作者查詢全國書目
作者(中文):楊敬亭
作者(外文):Yang, Ching-Ting
論文名稱(中文):多壁奈米碳管/水泥複合材料之電磁屏蔽與熱傳導性質研究
論文名稱(外文):Electromagnetic interference shielding effectiveness and thermal conductivity of carbon nanotube/cement composites
指導教授(中文):徐文光
指導教授(外文):Hsu, Wen-Kuang
學位類別:碩士
校院名稱:國立清華大學
系所名稱:材料科學工程學系
學號:9731524
出版年(民國):99
畢業學年度:98
語文別:中文
論文頁數:49
中文關鍵詞:水泥奈米碳管電磁波屏蔽熱傳導係數
外文關鍵詞:cementcarbon nanotubeElectromagnetic interference shieldingthermal conductivity
相關次數:
  • 推薦推薦:0
  • 點閱點閱:99
  • 評分評分:*****
  • 下載下載:6
  • 收藏收藏:0
本研究將酸化處理的多壁奈米碳管與水泥以超音波震盪與機械式拌合製成奈米碳管/水泥複合材料,發現添加1wt%以上的碳管能夠提升奈米碳管/水泥複合材的電磁波屏壁效能,但亦發現過多的碳管添加會產生聚集並使熱傳導係數與抗壓強度下降。
In this study, shielding of electromagnetic interference by composites made from multi-walled carbon nanotubes and cement is tested at radiofrequency and improved shielding effectiveness is realized at the expense of decrease in compressive strength and thermal conductivity.
總目錄
摘要 ii
Abstract ii
總目錄 iii
圖目錄 vi
表目錄 viii
第一章 研究動機 1
第二章 文獻回顧 1
2-1 水泥 1
2-1-1水泥的歷史 1
2-1-2成分 3
2-1-3水化反應 4
2-1-4微結構 6
2-1-5熱性質 6
2-2奈米碳管 7
2-2-1奈米碳管的基本結構 7
2-2-2奈米碳管的電性 8
2-2-3奈米碳管的熱傳導係數 9
2-2-4 奈米碳管的機械性質 12
2-3多壁奈米碳管/水泥複合材料 12
2-4電磁波屏壁 13
2-4-1 電磁波所造成的影響 13
2-4-2 電磁波屏壁機制 16
第三章 實驗方法 18
3-1實驗藥品與儀器 18
3-2實驗步驟 19
3-2-1多壁奈米碳管酸化 19
3-2-2多壁奈米碳管/水泥複合材製備 21
3-2-3拉曼光譜量測 23
3-2-4水氣吸附量測 23
3-2-5總孔洞面積與平均孔徑量測 24
3-2-6熱擴散係數與比熱量測 24
3-2-7電阻率量測 25
3-2-8電磁波屏壁效能、介電係數與導磁係數量測 25
3-2-9抗壓強度量測 25
第四章 結果與討論 26
4-1 奈米碳管/水泥複合材之形貌與奈米碳管之分散性 26
4-1-1 掃瞄式電子顯微鏡(SEM) 26
4-1-2 拉曼光譜 29
4-1-3 水氣吸附 31
4-1-4 水銀測孔 33
4-2熱性質、電磁波屏壁與抗壓強度 35
4-2-1 熱性質 35
4-2-2 電磁波屏壁 37
4-2-3 抗壓強度 43
第五章 結論 45
第六章 參考資料 46

圖目錄
圖 1 混凝土組成 2
圖 2 水化產物產量與時間關係圖 5
圖 3 單層石墨捲曲成碳管之示意圖 8
圖 4多壁奈米碳管的熱傳導係數與溫度關係圖 11
圖 5奈米碳管、單層石墨、石墨之熱傳導係數與溫度之關係理論值 11
圖 6 酸化碳管與CH或CSH反應示意圖 13
圖 7 多壁奈米碳管酸化流程圖 20
圖 8 多壁奈米碳管/水泥複合材製備流程圖 22
圖 9 0wt%樣品SEM照片-1 27
圖 10 1wt%樣品SEM照片 27
圖 11 3wt%樣品SEM照片 28
圖 12 3wt%樣品SEM照片 28
圖 13 3wt%樣品與酸化多壁奈米碳管之拉曼光譜 30
圖 14 3wt%樣品與純水泥之拉曼光譜 30
圖 15不同碳管濃度試片之單位面積水氣吸附 32
圖 16 碳管濃度提高使水氣吸附面積增加示意圖 32
圖 17 不同分散狀況與水氣吸附量之關係 32
圖 18 相同碳管濃度時不同分散程度對於水氣吸附面積影響之示意圖 32
圖 19 不同碳管濃度試片之平均孔洞半徑與孔洞總面積 34
圖 20不同碳管濃度與孔洞半徑示意圖 34
圖 21 熱性質與碳管添加量之關係圖 36
圖 22 不同碳管濃度試片之電磁波屏壁效率 38
圖 23不同碳管濃度試片電磁波反射與入射之強度比 38
圖 24不同碳管濃度試片電磁波吸收與入射之強度比 39
圖 25不同碳管濃度試片之特徵阻抗 39
圖 26不同碳管濃度試片之導磁率 40
圖 27不同碳管濃度試片之導磁率虛部 40
圖 28 不同碳管濃度試片之電阻率與導電率 41
圖 29 不同碳管濃度試片之介電係數實部對頻率之關係 41
圖 30 不同碳管濃度試片之介電係數虛部對頻率之關係 42
圖 31 不同碳管同度試片之抗壓強度 44

表目錄
表 1波特蘭水泥成分 3
表 2水泥化學簡寫符號 4
表 3 水泥各成分在水化反應時之性質 5
表 4 水泥微結構組成與特性 6
1. Aspdin, J., An Improvement in the Modes of Producing an Artificial Stone. 1824: British.
2. Aïtcin, P.-C., Cements of yesterday and today: Concrete of tomorrow. Cement and Concrete Research, 2000. 30(9): p. 1349-1359.
3. ASTM, Standard Specification for Portland Cement. 2009.
4. Richardson, I.G. and G.W. Groves, Microstructure and Microanalysis of Hardened Ordinary Portland-Cement Pastes. Journal of Materials Science, 1993. 28(1): p. 265-277.
5. 沈永年、王和源, 混凝土技術. 2004, 臺北市: 全華.
6. Taylor, H.F.W., Cement chemistry. 2nd ed. ed. 1997, London: T. Telford.
7. 黃兆龍, 混凝土性質與行為. 1997, 台北: 詹氏書局.
8. Fu, X. and D.D.L. Chung, Effects of silica fume, latex, methylcellulose, and carbon fibers on the thermal conductivity and specific heat of cement paste. Cement and Concrete Research, 1997. 27(12): p. 1799-1804.
9. Kim, K.H., et al., An experimental study on thermal conductivity of concrete. Cement and Concrete Research, 2003. 33(3): p. 363-371.
10. Iijima, S., Helical Microtubules of Graphitic Carbon. Nature, 1991. 354(6348): p. 56-58.
11. Berber, S., Y.K. Kwon, and D. Tomanek, Unusually high thermal conductivity of carbon nanotubes. Physical Review Letters, 2000. 84(20): p. 4613-4616.
12. Thostenson, E.T., Z.F. Ren, and T.W. Chou, Advances in the science and technology of carbon nanotubes and their composites: a review. Composites Science and Technology, 2001. 61(13): p. 1899-1912.
13. Dresselhaus, M.S. and P.C. Eklund, Phonons in carbon nanotubes. Advances in Physics, 2000. 49(6): p. 705-814.
14. Hassanien, A., et al., Geometrical structure and electronic properties of atomically resolved multiwall carbon nanotubes. Applied Physics Letters, 1999. 75(18): p. 2755-2757.
15. Lambin, P., Electronic structure of carbon nanotubes. Comptes Rendus Physique, 2003. 4(9): p. 1009-1019.
16. Kim, P., et al., Thermal transport measurements of individual multiwalled nanotubes. Physical Review Letters, 2001. 8721(21): p. -.
17. Mingo, N. and D.A. Broido, Carbon nanotube ballistic thermal conductance and its limits. Physical Review Letters, 2005. 95(9): p. -.
18. Lourie, O., D.M. Cox, and H.D. Wagner, Buckling and collapse of embedded carbon nanotubes. Physical Review Letters, 1998. 81(8): p. 1638-1641.
19. Yu, M.F., T. Kowalewski, and R.S. Ruoff, Structural analysis of collapsed, and twisted and collapsed, multiwalled carbon nanotubes by atomic force microscopy. Physical Review Letters, 2001. 86(1): p. 87-90.
20. Yu, M.F., et al., Strength and breaking mechanism of multiwalled carbon nanotubes under tensile load. Science, 2000. 287(5453): p. 637-640.
21. Treacy, M.M.J., T.W. Ebbesen, and J.M. Gibson, Exceptionally high Young's modulus observed for individual carbon nanotubes. Nature, 1996. 381(6584): p. 678-680.
22. Wong, E.W., P.E. Sheehan, and C.M. Lieber, Nanobeam mechanics: Elasticity, strength, and toughness of nanorods and nanotubes. Science, 1997. 277(5334): p. 1971-1975.
23. Makar JM, B.J., Carbon nanotubes and their application in the construction industry Proceedings of 1st International Symposium on Nanotechnology in Construction, 2003: p. 331-341.
24. Li, G.Y., P.M. Wang, and X.H. Zhao, Mechanical behavior and microstructure of cement composites incorporating surface-treated multi-walled carbon nanotubes. Carbon, 2005. 43(6): p. 1239-1245.
25. de Ibarra, Y.S., et al., Atomic force microscopy and nanoindentation of cement pastes with nanotube dispersions. Physica Status Solidi a-Applications and Materials Science, 2006. 203(6): p. 1076-1081.
26. Wansom, S., et al., AC-impedance response of multi-walled carbon nanotube/cement composites. Cement & Concrete Composites, 2006. 28(6): p. 509-519.
27. Li, G.Y., P.M. Wang, and X.H. Zhao, Pressure-sensitive properties and microstructure of carbon nanotube reinforced cement composites. Cement & Concrete Composites, 2007. 29(5): p. 377-382.
28. Han, B.G., X. Yu, and E. Kwon, A self-sensing carbon nanotube/cement composite for traffic monitoring. Nanotechnology, 2009. 20(44): p. -.
29. Xun Yu, E.K., A carbon nanotube/cement composite with piezoresistive properties. SMART MATERIALS AND STRUCTURES, 2009. 18.
30. 罗健林, 段., 巴基管水泥复合材料的I-V特性及力学强度. 武汉工程大学学报, 2009. 31(1).
31. 罗健林, 段., 李惠, 纳米级硅灰及碳管对水泥基材料减振性能的影响. 材料工程, 2009. 2009(4).
32. Chan, L.Y. and B. Andrawes, Finite element analysis of carbon nanotube/cement composite with degraded bond strength. Computational Materials Science, 2010. 47(4): p. 994-1004.
33. Konsta-Gdoutos, M.S., Z.S. Metaxa, and S.P. Shah, Multi-scale mechanical and fracture characteristics and early-age strain capacity of high performance carbon nanotube/cement nanocomposites. Cement & Concrete Composites, 2010. 32(2): p. 110-115.
34. 孫德霖, 多壁奈米碳管/水泥複合材料之合成與物理性質研究, in 材料科學與工程研究所. 2010, 國立清華大學: 新竹.
35. Park, H.J., et al., The effect of pre-treatment methods on morphology and size distribution of multi-walled carbon nanotubes. Nanotechnology, 2008. 19(33): p. -.
36. UNFCCC, Kyoto Protocol to the United Nations Framework Convention on Climate Change. 1997.
37. 刘顺华, 刘., 董星龙, 电磁波屏蔽及吸波材料. 2007: 化学工业出版社.
38. 世界衛生組織於2010年5月表示,目前相關研究並無法證實行動電話使用與腦瘤之關係。但因行動電話使用者年齡下降與使用時間增加,必須要投入更多的研究來補足此一領域之知識空缺。.
39. 通訊元件教學推動中心, 電磁相容理論與實務. 2007, 臺北市.
40. Sahoo, N.G., et al., Improvement of mechanical and thermal properties of carbon nanotube composites through nanotube functionalization and processing methods. Materials Chemistry and Physics, 2009. 117(1): p. 313-320.
41. Hsu, C.-T., Phonon and adsorption properties of aggregated carbon nanotubes and novel productions for tubular graphite and individual graphenes, in Material science and engineering. 2008, National TsingHua University: HsinChu.
42. 內政部營建署, 建築技術規則 -建築設計施工編-第二章 第八節.
43. 前述所引用之規範使新型態的建築(如薄膜式遮頂)無法發展,因此在民國九十三年三月十日已第八節第四十五條刪除,但我們還是可以知道一般建築物的熱傳透是不宜過高的。.
44. Watts, P.C.P., et al., High permittivity from defective multiwalled carbon nanotubes in the X-band. Advanced Materials, 2003. 15(7-8): p. 600-603.
45. Mc Carthy, B., et al., Spectroscopic investigation of conjugated polymer/single-walled carbon nanotube interactions. Chemical Physics Letters, 2001. 350(1-2): p. 27-32.
46. Watts, P.C.P. and W.K. Hsu, Verification of electromagnetic induction from Fe-filled carbon nanotubes. Applied Physics a-Materials Science & Processing, 2004. 78(1): p. 79-83.
47. Zhongdong Duan, J.L. Effect of multi-walled carbon nanotubes on the vibration-reduction behavior of cement. in International Conference on Smart Materials and Nanotechnology in Engineering. 2007.
48. Sanchez, F. and C. Ince, Microstructure and macroscopic properties of hybrid carbon nanofiber/silica fume cement composites. Composites Science and Technology, 2009. 69(7-8): p. 1310-1318.
49. Joachim Roesler, H.H., Martin Baeker, Mechanical Behaviour of Engineering Materials. 2007: Springer.
50. Coleman, J.N., U. Khan, and Y.K. Gun'ko, Mechanical reinforcement of polymers using carbon nanotubes. Advanced Materials, 2006. 18(6): p. 689-706.
 
 
 
 
第一頁 上一頁 下一頁 最後一頁 top
* *